牛羊、生猪屠宰污水处理设备工艺介绍
生猪、牛、羊屠宰污水有机物浓度高，悬浮物多，油脂含量大，需采用组合工艺高效处理。
核心工艺流程如下：
1. 预处理段：污水首先经格栅拦截毛发、碎肉等大颗粒物。随后进入隔油沉淀池，去除浮油及沉降性杂质。气浮单元可进一步乳化细小微粒与油脂，为生化处理创造条件。
2. 生化处理段：此为关键环节。普遍采用“厌氧+好氧”组合。厌氧工艺（如UASB、水解酸化池）有效降解高浓度有机物，降低后续负荷。好氧工艺（如活性污泥法、接触氧化法）深度去除剩余有机物及氨氮，确保COD、BOD达标。
3. 深度处理与消毒：生化出水经沉淀池泥水分离后，若标准严格，可增加深度处理（如过滤、膜分离）。最后必须投加消毒剂（如次氯酸钠、紫外线）杀灭病原菌，保证出水安全排放或回用。#屠宰污水处理设备 #屠宰场污水处理设备 #肉制品解冻污水处理设备 #生猪屠宰污水处理设备 #牛羊屠宰污水处理设备
Introduction of Sewage Treatment Equipment for Cattle, Sheep and Pig Slaughtering Slaughtering wastewater of pig, cattle and sheep has high concentration of organic matter, suspended solids and grease, so it needs to be treated efficiently by combined process. The core process flow is as follows: 1. Pretreatment section: The sewage first intercepts large particles such as hair and minced meat through the grille. And then enter an oil separation sedimentation tank to remove floating oil and settle impurities. The air floatation unit can further emulsify fine particles and grease to create conditions for biochemical treatment. treatment section: this is the key link. The combination of "anaerobic + aerobic" is widely used. The anaerobic process (such as UASB and hydrolysis acidification tank) can effectively degrade the high-concentration organic matters and reduce the subsequent load. Aerobic process (such as activated sludge process and contact oxidation process) can deeply remove residual organic matter and ammonia nitrogen to ensure that COD and BOD meet the standards. 3. Advanced treatment and disinfection: After the biochemical effluent is separated from the sludge in the sedimentation tank, if the standard is strict, advanced treatment (such as filtration and membrane separation) can be added. Finally, disinfectants (such as sodium hypochlorite and ultraviolet rays) must be added to kill pathogenic bacteria and ensure the safe discharge or reuse of effluent. # Slaughtering sewage treatment equipment # # Meat product thawing sewage treatment equipment #
生猪、牛、羊屠宰污水有机物浓度高，悬浮物多，油脂含量大，需采用组合工艺高效处理。
核心工艺流程如下：
1. 预处理段：污水首先经格栅拦截毛发、碎肉等大颗粒物。随后进入隔油沉淀池，去除浮油及沉降性杂质。气浮单元可进一步乳化细小微粒与油脂，为生化处理创造条件。
2. 生化处理段：此为关键环节。普遍采用“厌氧+好氧”组合。厌氧工艺（如UASB、水解酸化池）有效降解高浓度有机物，降低后续负荷。好氧工艺（如活性污泥法、接触氧化法）深度去除剩余有机物及氨氮，确保COD、BOD达标。
3. 深度处理与消毒：生化出水经沉淀池泥水分离后，若标准严格，可增加深度处理（如过滤、膜分离）。最后必须投加消毒剂（如次氯酸钠、紫外线）杀灭病原菌，保证出水安全排放或回用。#屠宰污水处理设备 #屠宰场污水处理设备 #肉制品解冻污水处理设备 #生猪屠宰污水处理设备 #牛羊屠宰污水处理设备
Introduction of Sewage Treatment Equipment for Cattle, Sheep and Pig Slaughtering Slaughtering wastewater of pig, cattle and sheep has high concentration of organic matter, suspended solids and grease, so it needs to be treated efficiently by combined process. The core process flow is as follows: 1. Pretreatment section: The sewage first intercepts large particles such as hair and minced meat through the grille. And then enter an oil separation sedimentation tank to remove floating oil and settle impurities. The air floatation unit can further emulsify fine particles and grease to create conditions for biochemical treatment. treatment section: this is the key link. The combination of "anaerobic + aerobic" is widely used. The anaerobic process (such as UASB and hydrolysis acidification tank) can effectively degrade the high-concentration organic matters and reduce the subsequent load. Aerobic process (such as activated sludge process and contact oxidation process) can deeply remove residual organic matter and ammonia nitrogen to ensure that COD and BOD meet the standards. 3. Advanced treatment and disinfection: After the biochemical effluent is separated from the sludge in the sedimentation tank, if the standard is strict, advanced treatment (such as filtration and membrane separation) can be added. Finally, disinfectants (such as sodium hypochlorite and ultraviolet rays) must be added to kill pathogenic bacteria and ensure the safe discharge or reuse of effluent. # Slaughtering sewage treatment equipment # # Meat product thawing sewage treatment equipment #
